Kx250f Clutch Cable Adjustment

Pulling the lever to your fingers should be enough to disengage the clutch.

Kx250f clutch cable adjustment.

Periodic maintenance chart air filter servicing brake fluid brake inspection clutch cable adjustment. 2004 2005 kx250f part 99924 1324 03. Page 3 quick reference guide general information periodic maintenance fuel system dfi cooling system engine top end clutch engine lubrication system engine removal installation crankshaft transmission wheels tires 10 j final drive 11 j brakes 12 j suspension 13 j steering 14 j frame 15 j electrical system 16 j appendix. This manual covers 2011 2016 kawasaki kx250f motocross bikes.

Note be sure that the outer cable end at the clutch lever is fully seated in the adjuster at the clutch lever or it could slip into the place later. You should adjust the cable at the handlebars until it has loads of play and hardly moves the cable when you use the lever then adjust the same cable at the gearbox end until it comes back into acceptable range with correct amount of play then tighten locknut. Enjoy the videos and music you love upload original content and share it all with friends family and the world on youtube. Kawasaki kx250f service manual clutch adjustment engine right side kawasaki kx250f service manual oem parts for kawasaki 2009 kawasaki kx250f owner manual.

This is just taking up normal wear in the clutch. Periodic maintenance 2 27 periodic maintenance procedures clutch lever free play adjustment turn the adjuster a so that the clutch lever b will have 8 13 mm 0 3 0 5 in of play. You need to replace the clutch cable. If the former owner couldn t find the manual it is possible forgot to lube the cable.

When you become a subscriber you get the following information. Kawasaki kx250f periodic maintenance. 2011 kx250yb 2012 kx250yc 2013 kx250zd 2014 kx250ze 2015 kx250zf 2016 kx250zg. And do this adjustment process again.

You have three ways of adjusting cable slack. Clutch drag when cold is normal does it stall lurch or creep forward once it s warmed up after say a 10 min ride as for clutch adjustment your lever should have between 0 5 1 0 mm free play between the lever and perch. Hopefully a minor adjustment and you ll be good to go. If the clutch is really stiff compared to another 500 then it probably would be worth replacing the cable.